熔融还原炼铁工艺环保可行性初步研究——以广州珠江钢铁为例

熔融还原炼铁技术是目前国内外高度重视的新一代炼铁技术,Corex和Hlsmelt是其中的代表工艺。文章就炼铁工艺在技术、环境、经济等方面有不同的要求而提出可行性判别指标,对Corex、HIsmelt与传统高炉工艺进行各判别指标的对比分析,并结合广州珠江钢铁有限责任公司现址建设炼铁项目这一实例从定性和定量的角度判别三种工艺的优劣,从而指出,对于珠钢现址,Corex和H／smelt比高炉技术更适应环保要求,更利于珠钢的未来发展,其中HIsmelt最具优势和竞争力。     

Degradation of chlorinated phenols by nanoscale zero-valent iron

Chlorophenols (CPs), as important contaminants in groundwater, are toxic and difficult to biodegrade. Recently nanoscale zero-valent iron received a great deal of attention because of its excellent performance in treating recalcitrant compounds. In this study, nanoscale zero-valent iron particles were prepared using chemical reduction, and the reductive transformations of three kinds of chlorinated phenols (2-CP, 3-CP, and 4-CP) by nanoscale zero-valent iron under different conditions were investigated. The transformation process of the CPs was shown to be dechlorination first, then cleavage of the benzene ring. The removal efficiency of the CPs varied as follows: 2-CP > 3-CP > 4-CP. The reactivity of CPs was associated with their energy of lowest unoccupied molecular orbit (E _LUMO). With the increase in initial concentrations of CPs, removal efficiency decreased a little. But the quantities of CPs reduced increased evidently. Temperature had influence on not only the removal efficiency, but also the transformation pathway. At higher temperatures, dechlorination occurred prior to benzene ring cleavage. At lower temperatures, however, the oxidation product was formed more easily. __________ Translated from China Environmental Science, 2006, 26(6): 698–702 [译自: 中国环境科学]     

城市污染河道沉积物AVS与重金属生物毒性研究

采集珠江三角洲典型城市污染河道佛山水道表层沉积物和上覆水样品,测定了沉积物AVS,Eh,SEM_Pb,SEM_Cd,SEM_Cu,SEM_Zn,SEM_Ni,SEM_Cr,及上覆水Eh,DO.同步进行了底栖动物调查,结合调查结果分析了城市污染河道沉积物AVS与重金属生物毒性的关系.主要研究SEM-AVS判据在判断城市重污染河道重金属生物有效性方面的作用.所测AVS最大值为69.579 μmol/g,最小值为0.339 μmol/g,均值为20.283 μmol/g;各采样站位∑SEM₅（SEM_Pb,SEM_Cd,SEM_Cu,SEM_Zn,SEM_Ni之和）最大值为23.067 μmol/g,最小值为1.062 μmol/g;底栖动物种类和数量均较少,且基本为耐污种,优势种为水丝蚓.13个采样站位中,∑SEM₅-AVS<0的有9个,MDS分析结果显示：这9个站位中的7个底栖动物群落结构相似程度高.这表明重污染河道沉积物重金属的生物毒性与SEM-AVS的值关系密切,SEM-AVS判据在判断重污染区域重金属的生物毒性方面具有较大作用;同时说明重污染河流重金属生物毒性比较复杂,不能完全由SEM-AVS解释.     

Arsenic and chromate removal from water by iron chips-Effects of anions

The purpose of this study is to estimate the removal efficiency of As and Cr (VI) by one kind of industrial waste — iron chips, as well as to estimate the effects of typical inorganic anions (sulfate, phosphate, and nitrate), and typical organic anions (citrate, oxalate, and humate) on As or Cr (VI) removal. The results showed that 98% of As (V) and 92% of As (III) could be removed from aqueous phase by the iron chips within 60 min. Compared with As species, Cr (VI) was removed much more rapidly and efficiently with 97% of Cr (VI) being removed within 25 min. The removal efficiency for arsenic was in the order: As (III) (sulfate), As (III) (nitrate) or As (III), As (III) (humate), As (III) (oxalate), As (III) (citrate), As (III) (phosphate), and for chromate was in the order: Cr (VI) (sulfate), Cr (VI) (phosphate) or Cr (VI) (nitrate) or Cr (VI) (oxalate), Cr (VI), Cr (VI) (citrate), Cr (VI) (humate). In all the treatments, pH level increased with time except for As (III), the removal of which was either without anions or in the presence of humate or nitrate.     

水源更换对给水管网水质的影响研究

为了研究水源更换对给水管网水质的影响,对北方A市水源更换过程中管网水质理化指标进行了监测分析.通过33 h的监测发现,由于水源水质不同造成管网水质化学不稳定,管网水水质部分指标发生了明显的下降,pH从7.54降到7.18,碱度从188　mg·L^-1降到117 　mg·L^-1,氯化物从310 　mg·L^-1降到132 　mg·L^-1（以Cl^-计）,电导率从0.176　S·m^-1降到0.087 　S·m^-1,钙离子和镁离子略有下降分别为15 　mg·L^-1和11 　mg·L^-1,这些都是由于滦河水质与黄河水质不同造成的;余氯在换水过程中发生了较复杂的变化,主要是由于水源更换造成耗氯量增加以及夜间用水量少造成管网水输配时间长引起的;pH、碱度、余氯的变化使得管网水中铁的含量增加,最高达到0.4 　mg·L^-1,超出饮用水标准规定的0.3 　mg·L^-1.通过分析水源更换过程中水质的变化,提出了控制管网水质稳定的方法主要有提高pH、增加碱度、投加缓蚀剂和严格保证出厂水及管网水水质指标特别是余氯等.     

漂白粉用于治理石化企业硫化氢恶臭气体的研究

实验采用填料吸收塔对漂白粉用于石化企业硫化氢恶臭的治理进行了初步研究,系统研究了漂白粉投加量、硫化氢浓度、进气流量、吸收氧化温度、液气比等因素对处理效果的影响。结果表明：室温下,漂白粉投加量为0．2g／100mL,液气比20L／m^3,进气浓度控制在7800mg／m^3以内,调整适宜的进气量,对硫化氢恶臭的去除率可以达到99％以上。漂白粉吸收氧化硫化氢恶臭气体不仅技术可行,而且费用低廉,操作方便,可以进行深入的研究,进行工业化放大。     

硫酸盐废水生物脱硫研究进展

含硫酸盐废水的污染是一个全球性的问题。生物脱硫技术处理该类废水具有投资少、成本低、去除率高,无二次污染等优点,而成为废水处理技术的前沿课题。文章简要介绍了生物脱硫技术的基本原理;描述了废水脱硫微生物种类及其影响因素;重点阐述了国内外硫酸盐废水生物脱硫工艺的沿革和最新进展,并在此基础上,提出了酸酸盐废水生物脱硫技术的发展前景。     

来源于土壤和灌溉水的砷在水稻根表及其体内的富集特性

采用土壤-玻璃珠联合培养的方式,选择2个氧化能力不同的水稻品种YY-1、94D-64(品系)和采自浙江富阳的土壤(砷的本底值为13.8 mg·kg-1),并设灌溉清水和含砷水2个处理(即在分蘖期、拔节期、孕穗期、开花期和灌浆期5个生育阶段灌溉含砷污水,随灌溉水进入土壤中砷的浓度为3.2mg·kg-1),研究了砷在土壤-根表铁氧化物-水稻系统中的累积规律以及土壤和灌溉水对水稻秸秆和籽粒富集砷的贡献程度.结果表明,水稻的秸秆生物量及其籽粒产量并没有受到不同来源砷的显著影响;灌溉含砷水处理的两品系水稻根表铁氧化物沉积的数量(YY-1∶196 g·kg-1,94D-64∶75.8 g·kg-1)高于对照(YY-1∶175g·kg-1,94D-64∶60.1 g·kg-1),但差异不显著.然而,在水稻5个不同的生育期灌溉含砷水均显著增加了砷在其根表及其体内不同部位的富集(94D-64籽粒中砷含量除外).没有灌溉含砷水的对照其秸秆和籽粒中累积的砷来源于土壤,而砷处理的水稻其秸秆和籽粒中富集的砷则来源于土壤和灌溉的含砷水.土壤对YY-1和94D-64秸秆中富集砷的贡献率分别为76.5%和71.O%,灌溉水的贡献率分别为23.5%和29.0%,2个水稻品系之间没有明显差异.YY-1籽粒中的砷66.4%来源于土壤,33.6%来源于含砷灌溉水,灌溉水对该品系籽粒中砷的富集贡献率较高.另一品系94D-64籽粒中砷84.8%来源于土壤,15.2%由灌溉水贡献,灌溉水对此品系籽粒累积砷的贡献率较低.来源于土壤和灌溉水的砷在水稻籽粒中的富集没有超出我国的国家食品卫生标准(0.7 mg·kg-1).     

氯化蒸馏废酸还原回收锗

以锗烟尘氯化蒸馏后的废盐酸为原料,以废铁为还原剂,使废酸中的有价金属锗以还原态沉淀富集在渣中,强化氧化氯化蒸馏回收四氯化锗,锗的综合回收率达94．10％。同时生产净水剂用液体氯化铁产品。     

我国废钢加工设备发展中的问题及管理建议

我国钢铁工业的快速发展,带动了废钢回收及废钢加工设备产业的发展。介绍了我国废钢加工设备的生产规模及现状,对废钢加工设备制造企业多元化发展现象进行分析,并对废钢加工设备制造企业的规范化管理提出合理化建议。